Cheyenne Culpepper 32827 965 Posted April 17, 2015 Share Posted April 17, 2015 It will start and run just fine until it warms up, then it staves for fuel but will run shortly on full choke. let it sit for a while and it starts right up again. If I blow in the tank when it starts starving it will run again for a while, sometimes just once other a few times. Replaced the filter, fuel line to engine, cleaned the tank and screen. any ideas? besides blowing in the tank more often... Link to post Share on other sites
Eyesa Horg 1,763 Posted April 17, 2015 Share Posted April 17, 2015 Sounds more like an ignition issue than fuel, judging by the cool down factor. Typical coil problem in humble experience. However, mine have run for a while b4 quitting. Link to post Share on other sites
Cheyenne Culpepper 32827 965 Posted April 17, 2015 Author Share Posted April 17, 2015 but it will run on eether when hot, and restarts or keeps running when I blow into the tank with force without cooling... Link to post Share on other sites
Hardpan Curmudgeon SASS #8967 6,044 Posted April 17, 2015 Share Posted April 17, 2015 Carburetor. Rebuild should be pretty simple. Might want to do the magnetos at the same time. Link to post Share on other sites
Charlie Plasters, SASS#60943 308 Posted April 17, 2015 Share Posted April 17, 2015 Is the gas tank vented? Maybe the vent line is clogged. Link to post Share on other sites
The Original Lumpy Gritz 7,496 Posted April 17, 2015 Share Posted April 17, 2015 Main jet is some-what clogged, a fuel carb rebuild is needed. Flush the gas tank also and filter the fuel that goes into that tank. LG Link to post Share on other sites
Boulder Canyon Bob# 32052L 404 Posted April 17, 2015 Share Posted April 17, 2015 Pilot jet Link to post Share on other sites
Ya Big Tree 144 Posted April 18, 2015 Share Posted April 18, 2015 Is the gas tank vented? Maybe the vent line is clogged. +1 I'd start here. It's the easiest. You could also run some Sea Foam through it and see if it clears any fouling. Link to post Share on other sites
Reuben McCoy Rankin # 34239 50 Posted April 18, 2015 Share Posted April 18, 2015 Sea Foam good stuff!!! Link to post Share on other sites
Matthew Duncan 1,552 Posted April 18, 2015 Share Posted April 18, 2015 Carbureter float stuck? Link to post Share on other sites
Cheyenne Culpepper 32827 965 Posted April 18, 2015 Author Share Posted April 18, 2015 I'll pick up some tomorrow after I shoot tomorrow and drop the bowl and check it.. as I think about it, when I blew into the tank, I cud hear air hissing from somewhere.... Link to post Share on other sites
tangleridge slim 0 Posted April 18, 2015 Share Posted April 18, 2015 check to see if it has a fuel pump being an older kohler it probably has a mechanical fuel pump it can be rebuilt easy to see if that is the problem rig another fuel can above carb for gravity feed also you can take fuel line loose from carb to see if pump is workin you will need a longer fuel line to pump fuel back into container I believe it has a 12HP kohler on it Link to post Share on other sites
Shorty Jack Hammer 54 Posted April 18, 2015 Share Posted April 18, 2015 I'm voting for partially clogged jet also, had that very thing happen to me a few years ago and that is what it was. Took the carb apart an flushed it all out, worked great. Link to post Share on other sites
JudgeBagodonuts 18 Posted April 18, 2015 Share Posted April 18, 2015 Run it with the fuel cap off and see if it dies. If it does not die, you either need to clean the vent line (if it has one) or needs a new vented fuel cap. If it dies, I'd be suspicious of the carb float. Every symptom you've described is fuel starvation. Assuming you've put in a fuel filter in the correct direction, and large enough diameter fuel line, there isn't much more to look at other than the tank vent, fuel pump, and carb. Had a case like this with a VW, similar symptoms. Turns out that the previous owner put a second fuel filter in and unusual spot. I found it when I was preparing to replace the fuel line after replacing the fuel pump, and the other filter. Link to post Share on other sites
Recommended Posts
Archived
This topic is now archived and is closed to further replies.