Subdeacon Joe Posted January 2, 2012 Share Posted January 2, 2012 US Navy Discovers Knot Tying is Still Important, Especially When it Comes to Tying off the Pilot’s Ladder Ship pilots, in case you’re not familiar, are required on board commercial ships as they enter port. These individuals are generally master mariners with a detailed understanding of the currents and navigational hazards within their particular domain, and they are widely regarded as having the most keen shiphandling skills of any mariner. Being a harbor pilot is one of the most highly sought after careers for a mariner, and thus, very competitive. It does however, involve personal risk to life and limb due to the fact in most cases, going to work involves scaling the side of a ship via a rope and plastic ladder that is hung over the side. This maneuver is a daily occurrence just outside of harbors and inlets around the world, in sometimes truly challenging weather and sea state conditions. The US Navy is no exception, and you’ll find a pilot on board their warships on every trip in and out of the harbor. On Monday however, the pilot assigned to the USS Howard, a guided missile destroyer stationed in San Diego, experienced the surprise of his life. A few miles out to sea, the pilot boat operator approached the warship, but immediately noticed blatant safety issues needed to be corrected. Noting the poor state of repair of the ladder hanging over the side, the pilot boat requested its replacement. After the swapping out the bad ladder, the pilot began his climb up the vertical grey-painted steel. Upon reaching the very top rung, disaster struck and the ladder slipped over the edge about 2 feet. The knots tying it to the ship had failed. Losing his footing, the Pilot held on to the ladder with one hand until finally his grip let go. He fell approximately 18 feet to the wavetops. In an email, Jacobsen Pilot Service’s President, Tom Jacobsen comments: The pilot boat was in the right position so that it wasn’t in the way of the Pilot’s fall, and could quickly turn around and rescue the Pilot. Our procedures worked absolutely perfectly; Mayday calls on VHF radio, Lifeguard boats launched immediately to the rescue, VTS plotting pilot boat & ships position, and even the Fire Boat was headed to the scene. All of our man overboard drills and boat upgrades paid off. The Pilot was in the water for only two minutes! Once back onboard the pilot boat Polaris, we got him back to the Pilot station, warmed him up in a hot shower, and then sent him to the medical clinic to be checked out. As of today I think he is OK. We’ll discuss this at our next Pilot Advisory council. Also we will discuss our ongoing problem with the US Navy on rigging pilot ladders and will update everyone on what steps we have taken. A US Navy spokesperson commented on this incident for us stating: The US Navy recognizes that there is inherent risk associated with operations at sea, and in particular, at-sea personnel transfers. We take all due precautions in preparation for arriving in port, including formal briefs to mitigate risk to the lowest level possible. An investigation into this incident is in progress. We asked one of our subject matter experts to give us an analysis of the pilot ladder in the above image. The following deficiencies were noted: 1. The steps are misaligned and possibly damaged due to wear and tear 2. The ladder is too long, should not be dragging in the water 3. The lines are not taught 4. The sling that is tied off at the step that is used by the crew to pull the ladder up, is not tied off low enough. 5. Those things are difficult to pull in and if there is so much ladder below it, it is not only hard to pull up, but likely pretty dangerous. 6. There is no hand rail at the top on the vessel for someone to grab onto as they are climbing up. 7. There is no one at the top to assist or watch the person climbing up. 8. The two rails that it is tied off from are both bent slightly the other way, never a good sign. Remember the discussion last week on knots? Link to comment Share on other sites More sharing options...
Badger Mountain Charlie SASS #43172 Posted January 2, 2012 Share Posted January 2, 2012 Something about the monkey and going in the hole or some such..... A good granny knot ought to hold it...... for now. Link to comment Share on other sites More sharing options...
Tom Foolery U.S.M. #2348 Posted January 2, 2012 Share Posted January 2, 2012 GOT DUCT TAPE TF Link to comment Share on other sites More sharing options...
Loophole LaRue, SASS #51438 Posted January 2, 2012 Share Posted January 2, 2012 Remember the old verse about "for lack of a nail, the shoe was lost; for lack of the shoe, a horse was lost; for lack of the horse, the rider was lost; for lack of the rider, the battle was lost; for loss of the battle, the kingdom was lost"...or something close. The smallest detail can have the most dire consequences, especially in an unforgiving setting like a ship underway. Onboard a ship (any ship, but particulalrly a warship) lack of attention to the details will quickly become noticeable when you can least afford it. Sloppy maintenance is an invitation to disaster, and there is no excuse here. Makes you wonder what else aboard is unattended to. Shame. LL Link to comment Share on other sites More sharing options...
Alpo Posted January 2, 2012 Share Posted January 2, 2012 Deficiency #3. After the guy is taught how to spell, then maybe he can be taught how to keep the line taut. Link to comment Share on other sites More sharing options...
Badger Mountain Charlie SASS #43172 Posted January 2, 2012 Share Posted January 2, 2012 We threw the rules out on spelling long ago, Alpo. Link to comment Share on other sites More sharing options...
Marshal Mo Hare, SASS #45984 Posted January 2, 2012 Share Posted January 2, 2012 We threw the rules out on spelling long ago, Alpo. We did, but the US Navy should not have, especially when addressing deficiencies. Reminds me of how careful I was when I wrote a response to USAREUR about deficiencies discovered during a Technical Proficiency Inspection. Link to comment Share on other sites More sharing options...
Dawg Hair, SASS #29557 Posted January 3, 2012 Share Posted January 3, 2012 We threw the rules out on spelling long ago, Alpo. Yeah, as long as you gets the concept........................don't wanna hurt the feelings of the under achievers........................ Link to comment Share on other sites More sharing options...
Guest Tennessee Stud, SASS# 43634 Life Posted January 3, 2012 Share Posted January 3, 2012 Knotty, Knotty I know some wimmen that can be awful knotty, knotty... in a good kinda way. ts Link to comment Share on other sites More sharing options...
Badger Mountain Charlie SASS #43172 Posted January 3, 2012 Share Posted January 3, 2012 I know some wimmen that can be awful knotty, knotty... in a good kinda way. ts :lol: Watch it TS, this is a family show. Link to comment Share on other sites More sharing options...
Recommended Posts
Archived
This topic is now archived and is closed to further replies.